1. <rp id="a1p6u"></rp>
        2. <tbody id="a1p6u"></tbody>

          <th id="a1p6u"><track id="a1p6u"></track></th>
        3. <tbody id="a1p6u"></tbody>
          <th id="a1p6u"></th>
        4. <button id="a1p6u"><acronym id="a1p6u"></acronym></button>

          1. 滁州牧風空壓設備有限公司

            ChuZhou MuFeng Pressure Equipment Co.,Ltd.

            空壓設備專業制造商

            服務熱線

            177-5502-7573

            language

            公司新聞

            造成空壓機排氣量不足的幾個原因

            信息來源: http://www.cafechaidee.com  時間:2020/11/27 8:10:23 

            一、入口空氣過濾器的故障,當過濾器中的積垢產生堵塞,就會使排氣量減少;而吸氣管過長,管徑較小,造成吸氣阻力增大時,就直接影響了排氣量。

            First, the failure of the inlet air filter, when the fouling in the filter is blocked, the exhaust volume will be reduced; while the suction tube is too long and the pipe diameter is small, when the suction resistance increases, the exhaust volume is directly affected.

            二、空壓機轉速過低會使排氣量下降:空氣壓縮機的排氣量是按規定的海拔高度、吸氣溫度、濕度設計的,如果在超過上述標準的高原上使用時,就會造成吸氣壓力降低,排氣量也隨之降低;傳送皮帶打滑一會降低空壓機的轉速,進而影響排氣量降低。

            Two, the air compressor speed is too low will reduce the exhaust volume: air compressor exhaust volume is designed according to the altitude, suction temperature, humidity, if it is used above the above standard plateau, the suction pressure will be reduced, the volume of exhaust will also decrease; transmission belt skid for a while to reduce the air compressor. Speed, and then affect the reduction of exhaust gas.

            三、由于零件磨損導致空壓機各配合間隙的變化而引起的:氣缸、活塞、活塞環磨損嚴重、超差,造成相關間隙增大,泄漏量增大,嚴重的話就影響了排氣量。

            Three. Due to the change of the clearance between the parts of the air compressor, the cylinder, piston and piston ring wear seriously and exceed the difference, resulting in the increase of the relative clearance and the increase of the leakage, so the amount of the exhaust is affected seriously.

            四、空壓機系統嚴重漏氣,主要是由于填料函不嚴密從而產生漏氣使氣量降低,究其原因:首先,是填料函本身制造時不合要求;其次,可能是在安裝時,活塞桿與填料函中心沒有對好,產生磨損、拉傷等造成的漏氣。

            Four, air compressor system serious leakage, mainly because the packing letter is not tight to produce gas leakage to reduce gas, the reason: first, the filling letter itself is not required when manufacturing; secondly, may be in the installation, the piston rod and filling center is not good, resulting in wear and tear, such as wear and tear.

            五、空壓機壓力閥的故障對排氣量的影響,主要是指吸、排氣閥的閥座與閥片間落入金屬碎片或其它雜物,造成關閉不嚴,形成漏氣。

            Five. The effect of the failure of the air compressor pressure valve on the volume of the exhaust, mainly refers to the falling of metal debris or other debris between the seat and the valve plate of the suction and exhaust valves, resulting in the closure of the valve and the formation of air leakage.

            此外,氣閥彈簧力與氣體力匹配的不好也會影響排氣量,彈力過強則使閥片開啟遲緩,彈力太弱則閥片關閉不及時,這樣不但影響了排氣量,嚴重的話會影響到功率的增加,甚至影響氣閥閥片、彈簧的使用壽命。

            In addition, the poor matching of the valve spring force and the gas force will also affect the volume of the exhaust. The excess of the elastic force makes the valve plate open slow, the elastic force is too weak and the valve plate is closed in time, which not only affects the volume of the exhaust, but also affects the increase of the power, and even the life of the valve disc and the spring.


            微信

            聯系地址:滁州市瑯琊區滁東三岔路

            總部電話:4000-338-569   固定電話:0550-3836133

            手機號碼:17755027573   企業郵箱:88152236@qq.com

            Copyright ? 滁州牧風空壓設備有限公司 All Rights Reserved 版權                                 技術支持:鑫澤科技
            国产娇小粉嫩学生免费网站_夜夜天天噜狠狠爱2019_A片人禽杂交ZOZO_亚洲国产成人久久综合碰碰